Skip to main content

High yield expression of an AHL-lactonase from Bacillus sp. B546 in Pichia pastoris and its application to reduce Aeromonas hydrophila mortality in aquaculture

Abstract

Background

Aeromonas hydrophila is a serious pathogen and can cause hemorrhagic septicemia in fish. To control this disease, antibiotics and chemicals are widely used which can consequently result in "superbugs" and chemical accumulation in the food chain. Though vaccine against A. hydrophila is available, its use is limited due to multiple serotypes of this pathogen and problems of safety and efficacy. Another problem with vaccination is the ability to apply it to small fish especially in high numbers. In this study, we tried a new way to attenuate the A. hydrophila infection by using a quorum quenching strategy with a recombinant AHL-lactonase expressed in Pichia pastoris.

Results

The AHL-lactonase (AiiAB546) from Bacillus sp. B546 was produced extracellularly in P. pastoris with a yield of 3,558.4 ± 81.3 U/mL in a 3.7-L fermenter when using 3-oxo-C8-HSL as the substrate. After purification with a HiTrap Q Sepharose column, the recombinant homogenous protein showed a band of 33.6 kDa on SDS-PAGE, higher than the calculated molecular mass (28.14 kDa). Deglycosylation of AiiAB546 with Endo H confirmed the occurrence of N-glycosylation. The purified recombinant AiiAB546 showed optimal activity at pH 8.0 and 20°C, exhibited excellent stability at pH 8.0-12.0 and thermal stability at 70°C, was firstly confirmed to be significantly protease-resistant, and had wide substrate specificity. In application test, when co-injected with A. hydrophila in common carp, recombinant AiiAB546 decreased the mortality rate and delayed the mortality time of fish.

Conclusions

Our results not only indicate the possibility of mass-production of AHL-lactonase at low cost, but also open up a promising foreground of application of AHL-lactonase in fish to control A. hydrophila disease by regulating its virulence. To our knowledge, this is the first report on heterologous expression of AHL-lactonase in P. pastoris and attenuating A. hydrophila virulence by co-injection with AHL-lactonase.

Background

Aeromonas hydrophila is a Gram-negative rod and behaves as an opportunistic pathogen in both aquatic and host environments [1–3]. It can cause hemorrhagic septicemia, resulting in fin and tail rot and epizootic ulcerative syndrome in juvenile and mature fish or intestinal and wound infection in humans [3–7]. Application of antibiotics and chemical drugs is a conventional method to control this disease, but generally results in the constant emergence of "superbugs" and chemical accumulation in the food chain [8, 9]. Consequently, a new method is required to prevent such a fish disease [8, 10]. Several studies have reported that vaccines against A. hydrophila infections may provide protection for farmed fish; however, no vaccines are commercially available due to multiple serotypes of this pathogen and problems of safety and efficacy [11, 12].

The pathogenicity of A. hydrophila depends on the production of potential virulence factors, such as exoproteases and exotoxin [13]. Production of exoproteases is under the control of quorum sensing [1, 6]. The findings that A. hydrophila harbors the AhyI/AhyR quorum-sensing system, utilizes AHL-dependent quorum-sensing to regulate the expression of virulent genes, and mediates the process of microbial infection and colonization in the host provide a potentially promising strategy to control A. hydrophila--quorum-quenching [1, 6, 7, 10, 13]. Quorum-quenching mechanism has been identified in many prokaryotic and eukaryotic organisms [10]. It can regulate microbial activities of host by interfering with bacterial quorum sensing [14, 15]. Many Gram-negative bacteria produce, secrete, and respond to small diffusible N-acyl-homoserine lactone (AHL) signals to communicate with each other and determine group behaviors; for example, bacteria can sense their population density by the concentration of signal molecules and release toxins synchronously for disease outbreak [16, 17]. Except for quorum-sensing inhibitors such as furanones and pyrrinones, degradation of quorum-sensing signals by quorum-quenching enzymes is another promising way [17–19]. Quorum-quenching enzymes include AHL-lactonase, AHL-acylase and paraoxonases (PONs) [20–23]. AHL-lactonase, belonging to the metallohydrolase superfamily, catalyzes the hydrolysis of homoserine lactone ring of AHL signals [24, 25] and is widely conserved in a range of bacterial species [26]. Unlike AHL-acylase and PONs, which have variable substrate spectra, AHL-lactonase shows distinct substrate specificity and only efficiently hydrolyses AHL signals [20, 21, 24].

The first AHL-degrading enzyme coding-gene (aiiA) was cloned from Bacillus sp. 240B1 and expressed in the plant pathogen Erwinia carotovora to attenuate E. carotovora pathogenicity by reducing AHL accumulation [23]. To date, AHL-lactonases from Bacillus spp. have been successfully obtained and expressed in several bacteria (i.e. plant pathogen E. carotovora, human pathogen Pseudomonas fluorescens, insecticide Bacillus thuringiensis and recombinant expression strain Escherichia coli) and plants (i.e. potato and tobacco) to quench quorum sensing of pathogens [27–31]. But little is known about the expression of AiiA in Pichia pastoris--a high-yield expression system [32–35]--and the use of AiiA in the form of enzyme preparation to quench quorum sensing of pathogens. Here, we cloned a gene from Bacillus sp. B546 encoding an AHL-lactonase and expressed the gene in P. pastoris to achieve high-yield production. A. hydrophila ATCC 7966, a type strain with the whole genome sequenced [7], is often related with hemorrhagic septicemia in cold-blooded animals including fish, reptiles, and amphibians [36] and was used to infect common carp (Cyprinus carpio carpio)--a popular pet fish--by co-injection with the recombinant AHL-lactonase. The attenuating effect of AHL-lactonase on the occurrence of hemorrhagic septicemia in fish was evaluated.

Results

Gene cloning and sequence analysis

Using the primers BT1 and BT2 designed specific for AHL-lactonases of Bacillus spp., the full-length 753-bp AHL-lactonase gene, aiiAB546, was cloned from Bacillus sp. B546. aiiAB546 encoded a 250-amino acid polypeptide with a calculated molecular mass of 28.14 kDa and a pI of 4.64. No signal peptide was predicted in the deduced amino acid sequence of aiiAB546 based on SignalP 3.0 analysis. One potential N-glycosylation site (Asn-Ser-Thr) was identified at the N terminus by NetNGlyc 1.0 Server. AiiAB546 exhibited the maximum amino acid sequence identity (98%) to the AHL-lactonase from B. thuringiensis followed by that of Bacillus sp. 240B1 (90%).

Expression and fermentation of recombinant AiiAB546in P. pastoris

The AHL-lactonase gene aiiAB546 was transformed into P. pastoris GS115 competent cells with pPIC9 vector. Positive transformants were screened using well-diffusion assays, and the transformant with the highest AHL-lactonase activity was used for fermentation in the shake flask and 3.7-L fermenter. In the shake-flask level, AHL-lactonase activity was up to 27.1 ± 3.2 U/mL after methanol induction at 25°C for 72 h. In the fermenter, the expression level of recombinant AiiAB546 gradually increased with the induction time, and reached 3,558.4 ± 81.3 U/mL after 132 h induction (Figure 1).

Figure 1
figure 1

Accumulation of cell wet weight and enzymatic activity with methanol induction over time in a 3.7-L fermenter.

Purification of recombinant AiiAB546 in shake-flasks

Recombinant AiiAB546 was purified to electrophoretic homogeneity by ammonium sulfate precipitation and anion exchange chromatography (Figure 2). The molecular weight of the purified AiiAB546 was 33.6 kDa based on SDS-PAGE analysis, which was higher than the predicted value (28.14 kDa). The protein concentration and AHL-lactonase activity of the purified recombinant AiiAB546 was 0.006 mg/mL and 17.97 ± 2.7 U/mL, respectively. The specific activity of the purified recombinant AiiAB546 was 2,995.3 ± 61.7 U/mg with 3-oxo-C8-HSL as the substrate.

Figure 2
figure 2

SDS-PAGE analysis of the purified and deglycosylated AiiA B546 . Lanes: M, protein molecular mass standards; 1, the deglycosylated AiiAB546 with Endo H; 2, the purified recombinant AiiAB546.

Deglycosylation and LC-ESI-MS/MS analysis

After treatment with Endo H, the deglycosylated AiiAB546 migrated as a single band of approximately 31.5 kDa on SDS-PAGE (Figure 2), still higher than the predicted value. To confirm the identity of the purified protein, five interval peptides--KLYFVPAGR, MTEEDRIVNILKR, ENFEDEVPFAGVDSELALSSIKR, KENPIVFFGHDIEQEK and AEYETAQHSEEYLK--were obtained from LC-ESI-MS/MS analysis and shared 100% identity with the deduced amino acid sequence of aiiAB546.

Enzyme characterization

Purified recombinant AiiAB546 had the optimum pH of 8.0, and retained more than 73% of the maximum activity at pH 6.5-8.9 (Figure 3a). Recombinant AiiAB546 was stable at pH 6.0-12.0, retaining more than 70% activity after pre-incubation at 37°C for 1 h (Figure 3b). The optimum temperature of recombinant AiiAB546 was 20°C; at 0 and 20-35°C, the enzyme maintained more than 60% of the highest activity (Figure 3c). Recombinant AiiAB546 exhibited thermal stability at 70°C, retaining more than 80% of the initial activity after pre-incubation at 70°C for 30 min (Figure 3d). After storage at 0°C for 3 months, the enzyme still maintained 98.4% of the original activity.

Figure 3
figure 3

Enzyme characterization of purified recombinant AiiA B546 . a: Effect of pH on the AHL-lactonase activity of AiiAB546. b: pH stability assay. After pre-incubating the enzyme at 25°C for 1 h in buffers of pH 5.0-12.0, the residual activity was measured in PBS buffer (pH 8.0) at 25°C. c: Effect of temperature on AHL-lactonase activity. d: Thermostability of recombinant AiiAB546. The enzyme was pre-incubated at 60 and 70°C in PBS buffer (pH 8.0), and aliquots were removed at specific time points for the measurement of residual activity at 25°C.

The purified recombinant AiiAB546 was protease-resistant (Figure 4). After incubation with trypsin, subtilisin A, collagenase and proleather at 37°C for 30 or 60 min, the enzyme maintained or enhanced its enzymatic activity

Figure 4
figure 4

Effect of proteases on AHL-lactonase activity. The residual AHL-lactonase activity was determined after treatment with proteases at a ratio of 1:10 (w/w; protease/AiiAB546) at 37°C for 30 or 60 min. CK indicates no proteases added.

The effect of different metal ions or chemical reagents on the activity of recombinant AiiAB546 is displayed in Table 1. A number of metal ions, including Na+, K+, Ca2+, Fe3+, Mn2+, exhibited positive effects on the enzyme activity at 1 and 10 mM, respectively. AHL-lactonase activity was enhanced by Mg2+, Zn2+ and EDTA at 10 mM but reduced at 1 mM, Li+, Pb2+ and β-mercaptoethanol promoted the enzyme activity at 1 mM but reduced at 10 mM. AHL-lactonase activity was significantly or completely inhibited by Cu2+, Cr3+, SDS, Hg2+ and Ag+ at both concentrations tested.

Table 1 Effects of metal ions and chemicals on the purified recombinant AiiAB546 activity

Recombinant AiiAB546 exhibited catalytic activities towards all of the tested AHLs, including C10-HSL (211,880 U/mL), C12-HSL (84,450 U/mL), C6-HSL (19,030 U/mL), 3-oxo-C6-HSL (6,450 U/mL), 3-oxo-C8-HSL (27.1 U/mL), and C8-HSL (3.32 U/mL).

Co-injection of recombinant AiiAB546 and A. hydrophila in common carp

Aeromonas hydrophila ATCC 7966 was detected AHLs producing positive by reporter strain Agrobacterium tumefaciens KYC 55 (Figure 5). The LD50 of A. hydrophila to common carp was estimated at day 4 after intraperitoneal injection with 108 cfu. When intraperitoneally injected with PBS buffer or AiiAB546 only for 4 days, no mortalities or pathogenic symptoms were observed. When intraperitoneally injected with AiiAB546 + A. hydrophila, the accumulated mortality at day 4 was 54.17 ± 11.79%, significantly lower than the average mortality rate (79.17 ± 5.89%) of the fish injected with 108 cfu of A. hydrophila (P < 0.05) (Figure 6). Co-injection of AiiAB546 and A. hydrophila decreased the mortality rate of common carp by nearly 25%. The LT50 of the fish injected with A. hydrophila was about 20 h, which was delayed to 38 h by co-injection of AiiAB546 and A. hydrophila.

Figure 5
figure 5

AHL production in A. hydrophila ATCC 7966. Screening of AHL production in A. hydrophila ATCC 7966 by reporter strain A. tumefaciens KYC55.

Figure 6
figure 6

Average cumulative mortality rate in common carp of four treatments within 4 days. Average cumulative mortality rate in common carp inoculated with sterile PBS buffer (CK), AiiAB546 (0.4 U), A. hydrophila (108 cfu) or AiiAB546 (0.4 U) + A. hydrophila (108 cfu). Each point or bar represents the mean of triplicate plus standard deviation, and those marked with "*" means significant difference (one-way ANOVA; P < 0.05) among the groups.

Discussion

AHLs-encoding genes (aiiA) have been expressed in several pathogens (i.e. E.carotovora and P. aeruginosa), plants (i.e. potato and tobacoo), B. thuringiensis and E. coli[23, 27–31]. Heterogenous expression of aiiA in pathogenic bacteria decreased the concentrations of auto-inducers, reduced the expression of several virulence factors (i.e. elastase and pyocyanin in P. aeruginosa) and attenuated the virulence of pathogens [23, 28–30]. Expression of aiiA in the insecticide B. thuringiensis conferred the strain with a strong biocontrol capacity against AHL-dependent pathogen E. carotovora when co-inoculated with the pathogen [37]. aiiA was also expressed in E. coli and purified to study the specificity of the enzyme [17, 24]. The recombinant E. coli was able to attenuate the pathogenicity of E. carotovora when co-inoculated together [17]. All of these results indicate that aiiA encoded a protein against bacterial pathogens by hampering their AHL-dependent quorum sense system. However, these transgenic strains have to be co-inoculated with AHL-dependent pathogens for disease control and consequently influence ecological security and the stable expression of aiiA in transgenic strains [31, 38]. Considering the achievements and shortcomings of previous studies, we proposed two major innovations in this study. One is that we successfully overexpressed aiiA in P. pastoris for high-yield fermentation. To our knowledge, this is the first heterologous expression of aiiA in P. pastoris. The other is that we applied AHL-lactonase directly instead of AHL-lactonase-producing strains to control AHL-dependent pathogens of animals. Co-injection of AiiAB546 with A. hydrophila in fish successfully attenuated the A. hydrophila infection. As far as we know, this is the first study to inject AHL-lactonase to control A. hydrophila infection in fish.

Expression of aiiAB546 in P. pastoris enhanced the production of AiiAB546 to 3,558.4 ± 81.3 U/mL, which was significantly higher than that expressed in E. coli (0.24 U/mL, data of our lab work not published). In addition to high expression level, recombinant AiiAB546 expressed in P. pastoris had more favorable properties for degrading AHLs in vivo. Firstly, recombinant AiiAB546 had broad substrate specificity, showing catalytic activity against C4-HSL, C6-HSL, C8-HSL, C10-HSL, C12-HSL, C14-HSL, 3-oxo-C6-HSL and 3-oxo-C8-HSL. Secondly, it showed preferable activity at the temperature range of 20-25°C and neutral and weak alkaline pHs, which are similar to the physicochemical conditions of the carp and their aquatic environment. Thirdly, recombinant AiiAB546 expressed in P. pastoris was remarkably stable up to 70°C, significantly better than that expressed in E. coli (retained 21.3% activity after incubation at 37°C for 30 min, data of our lab work not published). This difference could be ascribed to the post-translation modification of recombinant AiiAB546 expressed in P. pastoris[39–41]. Deglycosylation with Endo H (Figure 2) confirmed the occurrence of N-glycosylation, but didn't account for the complete weight difference. Except for N-glycosylation, the recombinant AiiAB546 expressed in P. pastoris may have other post-translation modifications, such as O-deglycosylation and phosphorylation. In addition to excellent thermodynamic stability, recombinant AiiAB546 also had other advantageous properties, such as protease-resistance, resistance to many metal ions, and excellent pH stability over a wide pH range. All these properties indicated the application potential of AiiAB546 in aquaculture as a good feed additive [42, 43].

Many bacterial pathogens use AHL-dependent quorum sensing to regulate virulence, such as the animal pathogen A. hydrophila[1, 3, 6, 13], plant pathogen E. carotovora[44] and mammalian pathogen P. aeruginosa[30, 44]. AHL production in pathogen A. hydrophila ATCC 7966 has been screened by reporter strain KYC 55 (Figure 5). This result is consistent with that of the lux RI homologs of this strain detected by blot hybridization [45]. It has been reported that virulence factors such as extracellular proteases and α-haemolysin are under the control of AHLs [6, 13]. Co-injection of AiiAB546 and A. hydrophila in common carp decreased the mortality rate and delayed LT50 of the fish. The results indicated that AiiAB546 probably reduced the AHL accumulation of A. hydrophila, which would affect related gene expression and allow the host to build up defense mechanism against A. hydrophila infection, and eventually contributed to the decreased mortality rate and delayed LT50 of the carp observed in the present study [1, 6, 15]. After injection with the enzyme, fish displayed no signs of stress or disease and no mortalities were observed, thus indicating that the enzyme is safe for carp applications. We assume that the innate immune system of common carp might include some components like AiiA, because the PONs from human and other mammalian species have high catalytic activities against long-chain AHL signals and might be one of the active components of mammalian innate immune systems [21, 22, 46, 47]. When incubated with A. hydrophila only, the fish began to die rapidly at 11 h; co-injection of A. hydrophila with AiiAB546 delayed time to 26 h. We conjectured that AiiAB546 probably disrupted A. hydrophila transmission in the fish and prevented the pathogen from overcoming the host defenses by destroying the quorum sensing system of A. hydrophila. It has been reported that quorum sensing system was used by pathogens to escape premature detection of host defenses and defeat the host successfully at the appropriate time [17, 48, 49]. The detailed underlying mechanisms of this process, such as which AHLs are hydrolyzed and which virulence genes are hampered, need further study.

Conclusions

We firstly expressed an AHL-lactonase gene in P. pastoris and achieved high-yield fermentation of AHL-lactonase at low cost. The recombinant AHL-lactonase had preferable properties for practical application in aquaculture, such as favorable optimal pH and temperature, excellent pH and temperature stability, high specific activity, good protease-resistance and efficient hydrolysis of AHL signals. We tried a novel application form of AHL-lactonase and successfully controlled A. hydrophila infection in carp by using the quorum quenching strategy. Co-injection of AHL-lactonase with A. hydrophila decreased the mortality rate and delayed the LT50, indicating that the enzyme played an important role in attenuating A. hydrophila infection in fish and suggesting a promising way to control outbreaks of A. hydrophila disease in aquaculture. This recombinant enzyme with excellent pH and temperature stability and protease-resistance has potential application by feeding in the aquaculture. It is not clear if the same benefit will be observed, and further research about this enzyme in application will be carried out to make it more rigorously and clearly. Direct application of AHL-lactonase by either injection or feeding to control A. hydrophila infection might be an effective alternative of antibiotics to avoid the emergence of antibiotic-resistant strains.

Materials and methods

Strains and culture conditions

Bacillus sp. B546 was isolated from the mud of a fish pond at Wuqing, Tianjin, China using minimal medium [50] containing 3-oxo-C6-HSL as the sole carbon source at 30°C for 6 days. Strain B546 was identified by comparison of its 16S rDNA sequence with known sequences in GenBank and preserved in the China General Microbiological Culture Collection (Beijing, China) under the registered number of CGMCC 3228.

Host strain P. pastoris GS115 was purchased from Invitrogen (USA). Minimal methanol medium, minimal dextrose medium, buffered glycerol-complex medium, buffered methanol-complex medium, fermentation basal salts medium, and PTM1 trace salts were prepared as described in the manual of the Pichia Expression Kit (Invitrogen).

Agrobacterium tumefaciens KYC 55 (pJZ372) (pJZ384) (pJZ410) [51] was used as reporter strain for AHL-degrading activity bioassay. The strain was cultivated at 28°C and 200 rpm for 12 h in LB medium containing 100 mg/mL spectinomycin, 100 mg/mL gentamicin, and 5 mg/mL tetracycline.

Aeromonas hydrophila ATCC 7966 was grown in Mueller-Hinton agar (Oxoid; Canada) containing 5% sheep erythrocytes at 30°C [52].

Plasmids and reagents

The pGEM-T Easy vector (Promega, USA) was used for gene cloning. Plasmid pPIC9 (Invitrogen) was used as expression vector. The DNA purification kit, restriction endonucleases and T4 DNA ligase were purchased from TaKaRa (Japan). Trypsin, α-chymotrypsin, subtilisin A, collagenase and proleather were all purchased from Sigma (USA). C4-HSL, C6-HSL, 3-oxo-C6-HSL, C8-HSL, 3-oxo-C8-HSL, C10-HSL, C12-HSL, and C14-HSL were products of Sigma and used as substrates of AHL-lactonase. Other chemicals were of chemical grade and commercially available (Tiangen & GreenFortune, China).

Cloning and sequencing of the AHL lactonase gene aiiAB546

The genomic DNA of Bacillus sp. B546 was extracted by Bacterial genome extraction kit (Tiangen, China) following the manufacturer's instructions and used as the template for the PCR amplification. Based on the conserved amino acid sequences of AHL lactonases from Bacillus spp. and known information [23], a specific primer set was designed as follows: BT1 (5'-GCGGAATTC ATGACAGTAAAGAAGCTTTATTTCG-3') and BT2 (5'-ATAGCGGCCGC CTATATATACTCTGGGAACAC-3') (the EcoR I and Not I restriction sites are in blod). The PCR conditions included denaturation at 94°C for 5 min; 30 cycles of 94°C, 30 s, 58°C, 30 s, and 72°C, 1 min; with a final extension at 72°C for 10 min. The PCR product (about 750 bp) was purified and ligated into the pGEM-T Easy vector for sequencing and BLAST analysis.

Sequence analysis

The nucleotide sequence was analyzed by the Vector NTI Suite10 software. SignalP 3.0 server was used to predict the signal peptide in the deduced amino acid sequence http://www.cbs.dtu.dk/services/SignalP/. The DNA and protein sequences were aligned with known sequences by the blastn and blastp programs http://www.ncbi.nlm.nih.gov/BLAST/, respectively. Glycosylation prediction was performed by NetOGlyc 3.1 and NetNGlyc 1.0 (http://www.cbs.dtu.dk/services/NetOGlyc, NetNGlyc).

Expression of aiiAB546 in P. pastoris

The recombinant pGEM-T Easy vector harboring aiiAB546 was digested by EcoR I and Not I, and cloned into the pPIC9 vector to construct the recombinant plasmid pPIC9-aiiAB546. The recombinant plasmid was linearized by digestion with Bgl II and then transformed into P. pastoris GS115 by electroporation at 1.5 kV in a 0.2-cm cuvette. Then, 800 μL ice-cold sorbitol solution was immediately added to the cuvette, and the mixture was incubated at 30°C for 3 days.

Positive transformants were further grown on minimal methanol and minimal dextrose plates at 30°C for 2 or 3 days. The selected transformants were inoculated into 3 mL buffered glycerol-complex medium and cultured at 30°C for 48 h with gentle shaking at 200 rpm. The cells were collected by centrifugation at 5,300 × g for 5 min at 4°C and suspended in 1 mL buffered methanol-complex medium. The cells were then cultured at 30°C and 200 rpm for 48 h.

The culture supernatants were subjected to AHL-lactonase activity bioassay to select the clone with highest enzyme activity.

AHL-lactonase activity bioassay

Reporter strain A. tumefaciens KYC 55 was used to evaluate AHL-lactonase activity by using well-diffusion assays. Agar plates for bioassay were prepared by mixing 3 mL of the culture of A. tumefaciens KYC 55 and 20 mL LB agar medium (1.2% agar) at 45°C and immediately pouring into a 90-mm petri dish at room temperature. Known volumes of 3-oxo-C8-HSL were added to the wells of 5-mm diameter punched in the middle of the agar plates and incubated at 28°C for 12 h. Sixty-microliter of 50 μg/mL X-gal was spread surrounding the wells for induction. The diameter of induced zones was measured, and the relationship between the amounts of 3-oxo-C8-HSL (Y, nM) and the square of radius (X, mm2) is: lnY = 1.381X-10.528 (r2 = 0.9965). The reaction system (200 μL) containing purified recombinant AiiAB546 (10 μL) and 24 nM 3-oxo-C8-HSL in 50 mM phosphate buffer (pH 8.0,) was incubated in a water bath at 25°C for 45 min and terminated by addition of 10% SDS to a final concentration of 2%. The reaction mixture was pipetted into agar plate wells to determine the amount of residual 3-oxo-C8-HSL based on the established formula. The reaction system without AiiAB546 served as control. One unit (U) of AHL-lactonase activity was defined as the amount of enzyme that hydrolyzed 1 nM of 3-oxo-C8-HSL per minute under the assay conditions.

Expression and purification of recombinant AiiAB546 in shake flasks

The clone with highest enzymatic activity was inoculated into 300 mL buffered glycerol-complex medium and cultured at 30°C for 48 h with gentle agitation at 200 rpm. The cells were collected by centrifugation at 5,300 × g, 4°C for 5 min and suspended in 100 mL buffered methanol-complex medium for growth at 30°C and 200 rpm for 72 h. The culture supernatant was collected at 10,000 × g at 4°C for 10 min and used for further purification.

Recombinant AiiAB546, in the culture supernatant was precipitated with 80% ammonium sulfate saturation, followed by centrifugation at 12,000 × g for 10 min, re-suspension in 20 mM Tris-HCl (pH 8.0), and dialysis in the same buffer overnight. The crude enzyme was loaded onto a HiTrap Q Sepharose XL 5 mL FPLC column (GE Healthcare, Sweden) equilibrated with Tris-HCl buffer. Protein was eluted by a linear gradient of NaCl (0-1 M) at a flow rate of 3 mL/min. The fractions with AHL-lactonase activity were collected and identified on SDS-12% PAGE. The protein concentration of the purified recombinant AiiAB546 was assayed by the Bradford method [53] with bovine serum albumin as standard. Enzyme activity of the purified recombinant AiiAB546 was measured by using well-diffusion assays (3-oxo-C8-HSL as the substrate).

Deglycosylation and LC-ESI-MS/MS analysis

The purified recombinant AiiAB546 was deglycosylated by Endo H at 37°C for 1 h following the manufacturer's instructions (New England Biolabs, USA). The deglycosylated enzyme was analyzed by SDS-PAGE. To identify the purified protein, the relevant protein band was excised from the SDS-PAGE gel, digested with trypsin, and analyzed by LC-ESI-MS/MS (Thermo Finnigan, USA). The results of LC-ESI-MS/MS were compared with the deduced amino acid sequence of aiiAB546.

Enzyme characterization of purified recombinant AiiAB546

To study the enzyme properties of purified recombinant AiiAB546, 3-oxo-C8-HSL was used as the substrate, and the reaction was carried out as described above.

The effect of pH on enzyme activity was determined at 25°C in buffers of pH ranging from 5.0 to 9.0. To study the effect of pH on enzyme stability, the purified enzyme was pre-incubated in different buffers of pH ranging from 5.0 to 12.0 at 37°C for 1 h and measured the AHL-lactonase activity under standard conditions. The buffers used were 0.1 M phosphate buffer for pH 5.0-8.0, 0.1 M Tris-HCl buffer for pH 8.0-9.0, and 0.1 M glycine-NaOH buffer for pH 9.0-12.0.

The optimum temperature of purified recombinant AiiAB546 was determined at the optimum pH over the temperature range from 0 to 60°C. Thermal stability was determined by measuring the residual enzyme activity under standard conditions after pre-incubation in 0.1 M phosphate buffer (pH 8.0) at 60°C and 70°C for various durations.

The effects of various metal ions and chemical reagents on the enzymatic activity of purified recombinant AiiAB546 were examined at 25°C in 0.1 M phosphate buffer (pH 8.0) containing 1 or 10 mM tested chemicals. The remaining enzyme activity was measured under the standard conditions as described above.

To determine resistance to proteolysis, purified recombinant AiiAB546 was incubated with either trypsin or α-chymotrypsin in 0.1 M Tris-HCl (pH 7.0), collagenase or subtilisin A in 0.1 M Tris-HCl (pH 7.5), or proleather in 0.1 M glycine-NaOH buffer (pH 10.0) at 37°C for different periods (30 or 60 min) at a ratio of 1:10 (w/w; protease/AiiAB546). Protease resistance was determined by measuring the residual enzyme activity after protease treatment.

The substrate specificity of purified recombinant AiiAB546 was studied by measuring the enzyme activity against AHLs with different acyl chain length and substitution. The substrates contained C6-HSL, C8-HSL, C10-HSL, C12-HSL, 3-oxo-C6-HSL, and 3-oxo-C8-HSL.

Fermentation of recombinant AiiAB546 in fermenter

Fermentation of the clone with the highest AHL-lactonase activity in shake flask was performed in a 3.7-L fermenter (Bioengineering KLF 2000, Switzerland). The colony was cultured in 40 mL yeast peptone dextrose (YPD) medium at 30°C, 200 rpm for 48 h and then transferred into 200 mL YPD for growth (30°C, 200 rpm) overnight to prepare the fermentation seed. The seed was inoculated into 2-L of basal salt medium containing PTM1 trace salt solution in the 3.7-L fermenter. The temperature was set at 30°C and the pH was maintained at 5.0 with 28% (v/v) NH3•H2O. The dissolved oxygen concentration was controlled by airflow and agitation.

The fermentation process was in reference of the Pichia Fermentation Process Guidelines (Invitrogen). Until the initial glucose in the fermentation medium was completely exhausted and the dissolved oxygen concentration level was up to 80%, a glucose-fed batch phase was started by a 25% (w/v) glycose feed at the rate of 36 mL/h/L for 4 h. In succession, the mixture containing 8:1 (v/v) 25% glucose/methanol was added at the rate of 9 mL/h/L for about 4 h; during this phase, the cells adapted to grow in methanol. When the dissolved oxygen concentration increased notably, the mixture was replaced by 100% methanol to initiate the methanol fed-batch phase. The final concentration of 100% methanol was about 0.3% (v/v) for 156 h, and the recombinant protein was induced during this phase. In these three phases, the dissolved oxygen concentration was kept above 20%.

During the induction and expression phase, culture samples were collected every day, and enzyme activity in the supernatant and cell wet weight were measured. The protein content in the supernatant was analyzed by SDS-PAGE.

Application in the control of bacterial disease in aquaculture

Aermonas hydrophila ATCC 7966 and A. tumefaciens KYC 55 were streaked in parallel on LB plates containing X-gal to screen strains producing AHL. Common carp of 1.3 ± 0.15 g were raised at the density of 8 fish/tank (10 L/tank) in an indoor recirculation aquaculture system with daily aeration by feeding with commercial dry food (Fishmeal 47.0%, soybean meal 24.0%, wheat flour 24.0%, fish oil 2.0%, Ca(H2PO4)2 2.2%, vitamin/mineral premix [54] 0.8%; proximate composition: crude protein 42.0%, crude lipid 7.2%) at a fixed supply of 0.7% of their body weight every day [55]. The water temperature was kept constant at 28 ± 1°C.

Cells of A. hydrophila ATCC 7966 grown in Mueller-Hinton agar containing 5% sheep erythrocytes at 220 rpm at 30°C for 12 h were washed with sterile PBS buffer (pH 7.3) three times, and suspended in PBS buffer as injection preparation. Purified recombinant AiiAB546 was suspended in PBS buffer (pH 7.3) before use.

To assess the lethal dose 50% (LD50) of A. hydrophila ATCC 7966, duplicated groups of 8 common carp (1.3 ± 0.15 g) were injected with 50 μL of serial dilutions of A. hydrophila ranging from 2.0 × 108 to 2.0 × 1010 cfu/mL, and control groups were injected with the same volume of PBS (pH7.3). Cumulative mortality was recorded for 4 days.

To determine if recombinant aiiAB546 had any influence on bacterial virulence, four treatments of common carp were designed and the fish of different groups injected intraperitoneally with 0.4 U AiiAB546, 0.4 U AiiAB546 + A. hydrophila of 108 cfu (AHLase + A. hydrophila), A. hydrophila of 108 cfu (A. hydrophila) or PBS buffer (control treatment) per fish in the volume of 50 μL when anesthetized by tricaine methanesulfonate (MS-222). Each treatment included triplicate groups and each group contained 8 fish. The system was aerated, and any dead specimens were removed daily for routine bacteriological examination [56]. Cumulative mortality of each treatment was recorded about every two hours for 4 days.

Nucleotide sequence accession number

The nucleotide sequence for the N-acyl homoserine lactonase gene (aiiAB546) from Bacillus sp. B546 has been deposited in the Genbank under accession no. GQ899185.

Abbreviations

QS:

quorum sensing

QQ:

quorum quenching

AHLs:

N-acyl homoserine lactones

AiiA:

N-Acyl homoserine lactone lactonase

PONs:

paraoxonases

YPD:

yeast peptone dextrose medium

C4-HSL:

N-butanoyl-L-homoserine lactone

C6-HSL:

N-hexanoyl-L-homoserine lactone

3-oxo-C6-HSL:

N-(3-oxohexanoyl)-L-homoserine lactone

C8-HSL:

N-octanoyl-L-homoserine lactone

3-oxo-C8-HSL:

N-β-oxooctanoyl-L-homoserine lactone

C10-HSL:

N-decanoyl-L-homoserine lactone

C12-HSL:

N-dodecanoyl-L-homoserinelactone

C14-HSL:

N-3-tetradecanoyl-L- homoserine lactone

MS-222:

tricaine methanesulfonate

Endo H:

endo-β-N-acetylglucosaminidase H

LC-ESI-MS/MS:

liquid chromatography-electrospray ionization-tandem mass spectrometry

AHLase:

N-Acyl homoserine lactonase

LD50:

half lethal concentration

LT50:

half lethal time.

References

  1. Swift S, Karlyshev AV, Fish L, Durant EL, Winson MK, Chhabra SR, Williams P, Macintyre S, Stewart GS: Quorum sensing in Aeromonas hydrophila and Aeromonas salmonicida: identification of the Lux RI homologs AhyRI and AsaRI and their cognate N-acylhomoserine lactone signal molecules. Journal of Bacteriology. 1997, 179: 5271-5281.

    CAS  Google Scholar 

  2. Lynch MJ, Swift S, Kirke DF, Keevil CW, Dodd CE, Williams P: The regulation of biofilm development by quorum sensing in Aeromonas hydrophila. Environmental Microbiology. 2002, 4: 18-28. 10.1046/j.1462-2920.2002.00264.x.

    Article  CAS  Google Scholar 

  3. Vivas J, Carracedo B, Riaño J, Razquin BE, López-Fierro P, Acosta F, Naharro G, Villena AJ: Behavior of an Aeromonas hydrophila aroA live vaccine in water microcosms. Applied and Environmental Microbiology. 2004, 70: 2702-2708. 10.1128/AEM.70.5.2702-2708.2004.

    Article  CAS  Google Scholar 

  4. Froquet R, Cherix N, Burr SE, Frey J, Vilches S, Tomas JM, Cosson P: Alternative host model to evaluate Aeromonas virulence. Applied and Environmental Microbiology. 2007, 73: 5657-5659. 10.1128/AEM.00908-07.

    Article  CAS  Google Scholar 

  5. Reith ME, Singh RK, Curtis B, Boyd JM, Bouevitch A, Kimball J, Munholland J, Murphy C, Sarty D, Williams J, Nash JH, Johnson SC, Brown LL: The genome of Aeromonas salmonicida subsp. salmonicida A449: insights into the evolution of a fish pathogen. BMC Genomics. 2008, 9: 427- 10.1186/1471-2164-9-427.

    Article  Google Scholar 

  6. Swift S, Lynch MJ, Fish L, Kirke DF, Tomás JM, Stewart GS, Williams P: Quorum sensing-dependent regulation and blockade of exoprotease production in Aeromonas hydrophila. Infection and Immunity. 1999, 67: 5192-5199.

    CAS  Google Scholar 

  7. Seshadri R, Joseph SW, Chopra AK, Sha J, Shaw J, Graf J, Haft D, Wu M, Ren Q, Rosovitz MJ, Madupu R, Tallon L, Kim M, Jin S, Vuong H, Stine OC, Ali A, Horneman AJ, Heidelberg JF: Genome sequence of Aeromonas hydrophila ATCC 7966T: jack of all trades. Journal of Bacteriology. 2006, 188: 8272-8282. 10.1128/JB.00621-06.

    Article  CAS  Google Scholar 

  8. Williams P: Quorum sensing: an emerging target for antibacterial chemotherapy?. Expert Opinion on Therapeutic Targets. 2002, 6: 257-274. 10.1517/14728222.6.3.257.

    Article  CAS  Google Scholar 

  9. Livermore DM: The need for new antibiotics. Clinical Microbiology and Infection. 2004, 4: 1-9. 10.1111/j.1465-0691.2004.1004.x.

    Article  Google Scholar 

  10. Dong YH, Wang LY, Zhang LH: Quorum-quenching microbial infections: mechanisms and implications. Philosophical Transactions of the Royal Society of London B: Biological Sciences. 2007, 362: 1201-1211. 10.1098/rstb.2007.2045.

    Article  CAS  Google Scholar 

  11. Vivas J, Carracedo B, Riaño J, Razquin BE, López-Fierro P, Acosta F, Naharro G, Villena AJ: Behavior of an Aeromonas hydrophila aroA live vaccine in water microcosms. Applied and Environmental Microbiology. 2004, 70: 2702-2708. 10.1128/AEM.70.5.2702-2708.2004.

    Article  CAS  Google Scholar 

  12. Hernanz Moral C, Flaño del Castillo E, López Fierro P, Villena Cortés A, Anguita Castillo J, Cascón Soriano A, Sánchez Salazar M, Razquín Peralta B, Naharro Carrasco G: Molecular characterization of the Aeromonas hydrophila aroA gene and potential use of an auxotrophic aroA mutant as a live attenuated vaccine. Infection and Immunity. 1998, 66: 1813-1821.

    CAS  Google Scholar 

  13. Sha J, Pillai L, Fadl AA, Galindo CL, Erova TE, Chopra AK: The type III secretion system and cytotoxic enterotoxin alter the virulence of Aeromonas hydrophila. Infection and Immunity. 2005, 73: 6446-6457. 10.1128/IAI.73.10.6446-6457.2005.

    Article  CAS  Google Scholar 

  14. Czajkowski R, Jafra S: Quenching of acyl-homoserine lactone-dependent quorum sensing by enzymatic disruption of signal molecules. Acta Biochimica Polonicol. 2009, 56: 1-16.

    CAS  Google Scholar 

  15. Zhang LH: Quorum quenching and proactive host defense. Trends in Plant Science. 2003, 8: 238-244. 10.1016/S1360-1385(03)00063-3.

    Article  CAS  Google Scholar 

  16. Fuqua C, Greenberg EP: Self perception in bacteria: quorum sensing with acylated homoserine lactones. Current Opinion of Microbiology. 1998, 1: 183-189. 10.1016/S1369-5274(98)80009-X.

    Article  CAS  Google Scholar 

  17. Lee SJ, Park SY, Lee JJ, Yum DY, Koo BT, Lee JK: Genes encoding the N-acyl homoserine lactone-degrading enzyme are widespread in many subspecies of Bacillus thuringiensis. Applied and Environmental Microbiology. 2002, 68: 3919-3924. 10.1128/AEM.68.8.3919-3924.2002.

    Article  CAS  Google Scholar 

  18. Hentzer M, Wu H, Andersen JB, Riedel K, Rasmussen TB, Bagge N, Kumar N, Schembri MA, Song Z, Kristoffersen P, Manefield M, Costerton JW, Molin S, Eberl L, Steinberg P, Kjelleberg S, Høiby N, Givskov M: Attenuation of Pseudomonas aeruginosa virulence by quorum sensing inhibitors. EMBO Journal. 2003, 22: 3803-3815. 10.1093/emboj/cdg366.

    Article  CAS  Google Scholar 

  19. Wu H, Song Z, Hentzer M, Andersen JB, Molin S, Givskov M, Høiby N: Synthetic furanones inhibit quorum-sensing and enhance bacterial clearance in Pseudomonas aeruginosa lung infection in mice. Journal of Antimicrobial Chemotherapy. 2004, 53: 1054-1061. 10.1093/jac/dkh223.

    Article  CAS  Google Scholar 

  20. Lin YH, Xu JL, Hu J, Wang LH, Ong SL, Leadbetter JR, Zhang LH: Acyl-homoserine lactone acylase from Ralstonia strain XJ12B represents a novel and potent class of quorum-quenching enzymes. Molecular Microbiology. 2003, 47: 849-860. 10.1046/j.1365-2958.2003.03351.x.

    Article  Google Scholar 

  21. Draganov DI, Teiber JF, Speelman A, Osawa Y, Sunahara R, La Du BN: Human paraoxonases (PON1, PON2, and PON3) are lactonases with overlapping and distinct substrate specificities. Journal of Lipid Research. 2005, 46: 1239-1247. 10.1194/jlr.M400511-JLR200.

    Article  CAS  Google Scholar 

  22. Yang F, Wang LH, Wang J, Dong YH, Hu JY, Zhang LH: Quorum quenching enzyme activity is widely conserved in the sera of mammalian species. FEBS Letters. 2005, 579: 3713-3717. 10.1016/j.febslet.2005.05.060.

    Article  CAS  Google Scholar 

  23. Dong YH, Xu JL, Li XZ, Zhang LH: AiiA, an enzyme that inactivates the acylhomoserine lactone quorum-sensing signal and attenuates the virulence of Erwinia carotovora. Proceedings of National Academy of Sciences USA. 2000, 97: 3526-3531. 10.1073/pnas.060023897.

    Article  CAS  Google Scholar 

  24. Wang LH, Weng LX, Dong YH, Zhang LH: Specificity and enzyme kinetics of the quorum-quenching N-Acyl homoserine lactone lactonase (AHL-lactonase). Journal of Biological Chemistry. 2004, 279: 13645-13651. 10.1074/jbc.M311194200.

    Article  CAS  Google Scholar 

  25. Kim MH, Choi WC, Kang HO, Lee JS, Kang BS, Kim KJ, Derewenda ZS, Oh TK, Lee CH, Lee JK: The molecular structure and catalytic mechanism of a quorum-quenching N-acyl-L-homoserine lactone hydrolase. Proceedings of National Academy of Sciences USA. 2005, 102: 17606-17611. 10.1073/pnas.0504996102.

    Article  CAS  Google Scholar 

  26. Dong YH, Zhang LH: Quorum sensing and quorum-quenching enzymes. Journal of Microbiology. 2005, 43: 101-109.

    CAS  Google Scholar 

  27. Dong YH, Wang LH, Xu JL, Zhang HB, Zhang XF, Zhang LH: Quenching quorum-sensing-dependent bacterial infection by an N-acyl homoserine lactonase. Nature. 2001, 411: 813-817. 10.1038/35081101.

    Article  CAS  Google Scholar 

  28. Ulrich RL: Quorum quenching: enzymatic disruption of N-acylhomoserine lactone-mediated bacterial communication in Burkholderia thailandensis. Applied and Environmental Microbiology. 2004, 70: 6173-6180. 10.1128/AEM.70.10.6173-6180.2004.

    Article  CAS  Google Scholar 

  29. Molina L, Constantinescu F, Michel L, Reimmann C, Duffy B, Défago G: Degradation of pathogen quorum-sensing molecules by soil bacteria: a preventive and curative biological control mechanism. FEMS Microbiology Ecology. 2003, 45: 71-81. 10.1016/S0168-6496(03)00125-9.

    Article  CAS  Google Scholar 

  30. Reimmann C, Ginet N, Michel L, Keel C, Michaux P, Krishnapillai V, Zala M, Heurlier K, Triandafillu K, Harms H, Défago G, Haas D: Genetically programmed autoinducer destruction reduces virulence gene expression and swarming motility in Pseudomonas aeruginosa PAO1. Microbiology. 2002, 148: 923-932.

    Article  CAS  Google Scholar 

  31. Zhang L, Ruan L, Hu C, Wu H, Chen S, Yu Z, Sun M: Fusion of the genes for AHL-lactonase and S-layer protein in Bacillus thuringiensis increases its ability to inhibit soft rot caused by Erwinia carotovora. Applied Microbiology and Biotechnology. 2007, 74: 667-675. 10.1007/s00253-006-0696-8.

    Article  CAS  Google Scholar 

  32. Kocken CH, Dubbeld MA, Wel Van Der A, Pronk JT, Waters AP, Langermans JA, Thomas AW: High-level expression of Plasmodium vivax apical membrane antigen 1 (AMA-1) in Pichia pastoris: strong immunogenicity in Macaca mulatta immunized with P. vivax AMA-1 and adjuvant SBAS2. Infection and Immunity. 1999, 67: 43-49.

    CAS  Google Scholar 

  33. Kocken CH, Withers-Martinez C, Dubbeld MA, Wel van der A, Hackett F, Valderrama A, Blackman MJ, Thomas AW: High-level expression of the malaria blood-stage vaccine candidate Plasmodium falciparum apical membrane antigen 1 and induction of antibodies that inhibit erythrocyte invasion. Infected Immunity. 2002, 70: 4471-4476. 10.1128/IAI.70.8.4471-4476.2002.

    Article  CAS  Google Scholar 

  34. Loukas A, Bethony JM, Mendez S, Fujiwara RT, Goud GN, Ranjit N, Zhan B, Jones K, Bottazzi ME, Hotez PJ: Vaccination with recombinant aspartic hemoglobinase reduces parasite load and blood loss after hookworm infection in dogs. PLoS Medicine. 2005, 2: e295- 10.1371/journal.pmed.0020295.

    Article  Google Scholar 

  35. Liu YY, Woo JH, Neville DM: Overexpression of an anti-CD3 immunotoxin increases expression and secretion of molecular chaperone BiP/Kar2p by Pichia pastoris. Applied and Environmental Microbiology. 2005, 71: 5332-5340. 10.1128/AEM.71.9.5332-5340.2005.

    Article  CAS  Google Scholar 

  36. Austin B, Austin D: Bacterial Fish Pathogens: Disease in Farmed and Wild Fish. 1987, Ellis Horwood, Chichester, Third Revised,

    Google Scholar 

  37. Dong YH, Zhang XF, Xu JL, Zhang LH: Insecticidal Bacillus thuringiensis silences Erwinia carotovora virulence by a new form of microbial antagonism, signal interference. Applied and Environmental Microbiology. 2004, 70: 954-960. 10.1128/AEM.70.2.954-960.2004.

    Article  CAS  Google Scholar 

  38. Muir J: Managing to harvest? Perspectives on the potential of aquaculture. Philosophical Transactions of the Royal Socienty of London, Series B: Biological Science. 2005, 360: 191-218. 10.1098/rstb.2004.1572.

    Article  Google Scholar 

  39. Shental-Bechor D, Levy Y: Effect of glycosylation on protein folding: a close look at thermodynamic stabilization. Proceedings of National Academy of Sciences USA. 2008, 105: 8256-8261. 10.1073/pnas.0801340105.

    Article  CAS  Google Scholar 

  40. Kern G, Schülke N, Schmid FX, Jaenicke R: Stability, quaternary structure, and folding of internal, external, and core-glycosylated invertase from yeast. Protein Science. 1992, 1: 120-131. 10.1002/pro.5560010112.

    Article  CAS  Google Scholar 

  41. Blanchard V, Gadkari RA, George AV, Roy S, Gerwig GJ, Leeflang BR, Dighe RR, Boelens R, Kamerling JP: High-level expression of biologically active glycoprotein hormones in Pichia pastoris strains-selection of strain GS115, and not X-33, for the production of biologically active N-glycosylated 15N-labeled phCG. Glycoconj Journal. 2008, 25: 245-257. 10.1007/s10719-007-9082-8.

    Article  CAS  Google Scholar 

  42. Mi S, Meng K, Wang Y, Bai Y, Yuan T, Luo H, Yao B: Molecular cloning and characterization of a novel α-galactosidase gene from Penicillium sp. F63 CGMCC 1669 and expression in Pichia pastoris. Enzyme and Microbial Technology. 2007, 7848: 1-8.

    Google Scholar 

  43. Li N, Shi P, Yang P, Wang Y, Luo H, Bai Y, Zhou Z, Yao B: Cloning, expression, and characterization of a new Streptomyces sp. S27 xylanase for which xylobiose is the main hydrolysis product. Applied Biochemistry and Biotechnology. 2009, 159: 521-531. 10.1007/s12010-008-8411-0.

    Article  CAS  Google Scholar 

  44. Jones S, Yu B, Bainton NJ, Birdsall M, Bycroft BW, Chhabra SR, Cox AJ, Golby P, Reeves PJ, Stephens S, Winson MK, Salmond GPC, Stewart GSAB, Williams P: The lux autoinducer regulates the production of exoenzyme virulence determinants in Erwinia carotovora and Pseudomonas aeruginosa. EMBO Journal. 1993, 12: 2477-2482.

    CAS  Google Scholar 

  45. Jangid K, Kong R, Patole MS, Shouche YS: lux RI homologs are universally present in the genus Aeromonas. BMC Microbiology. 2007, 7: 93- 10.1186/1471-2180-7-93.

    Article  Google Scholar 

  46. Chun CK, Ozer EA, Welsh MJ, Zabner J, Greenberg EP: Inactivation of a Pseudomonas aeruginosa quorum-sensing signal by human airway epithelia. Proceedings of the National Academy of Sciences USA. 2004, 101: 3587-3590. 10.1073/pnas.0308750101.

    Article  CAS  Google Scholar 

  47. Ozer EA, Pezzulo A, Shih DM, Chun C, Furlong C, Lusis AJ, Greenberg EP, Zabner J: Human and murine paraoxonase 1 are host modulators of Pseudomonas aeruginosa quorum-sensing. FEMS Microbiology Letters. 2005, 253: 29-37. 10.1016/j.femsle.2005.09.023.

    Article  CAS  Google Scholar 

  48. Mäe A, Montesano M, Koiv V, Palva ET: Transgenic plants producing the bacterial pheromone N-acyl-homoserine lactone exhibit enhanced resistance to the bacterial phytopathogen Erwinia carotovora. Molecular Plant and Microbe Interaction. 2001, 14: 1035-1042. 10.1094/MPMI.2001.14.9.1035.

    Article  Google Scholar 

  49. Fray RG, Throup JP, Daykin M, Wallace A, Williams P, Stewart GS, Grierson D: Plants genetically modified to produce N-acylhomoserine lactones communicate with bacteria. National Biotechnology. 1999, 17: 1017-1020. 10.1038/13717.

    Article  CAS  Google Scholar 

  50. Leadbetter JR, Greenberg EP: Metabolism of acyl-homoserine lactone quorum-sensing signals by Variovorax paradoxus. Journal of Bacteriology. 2000, 182: 6921-6926. 10.1128/JB.182.24.6921-6926.2000.

    Article  CAS  Google Scholar 

  51. Zhu J, Chai Y, Zhong Z, Li S, Winans SC: Agrobacterium bioassay strain for ultrasensitive detection of N-acylhomoserine lactone-type quorum-sensing molecules: detection of autoinducers in Mesorhizobium huakuii. Applied and Environmental Microbiology. 2003, 69: 6949-6953. 10.1128/AEM.69.11.6949-6953.2003.

    Article  CAS  Google Scholar 

  52. Wang G, Clark CG, Liu C, Pucknell C, Munro CK, Kruk TMAC, Caldeira R, Woodward DL, Rodgers FG: Detection and characterization of the hemolysin genes in Aeromonas hydrophila and Aeromonas sobria by multiplex PCR. Journal of Clinical Microbiology. 2003, 41: 1048-1054. 10.1128/JCM.41.3.1048-1054.2003.

    Article  CAS  Google Scholar 

  53. Bradford MM: A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Analysis of Biochemstry. 1976, 72: 248-254.

    Article  CAS  Google Scholar 

  54. Lv H, Zhou Z, Rudeaux F, Respondek F: Effects of dietary short chain fructo-oligosaccharides on intestinal microflora, mortality and growth performance of O. nilotica ♀ × O. aurea ♂. Chinese Journal of Animal Nutrition. 2007, 19: 691-697.

    CAS  Google Scholar 

  55. Mazon AF, Huising MO, Taverne-Thiele AJ, Bastiaans J, Verburg-van Kemenade BM: The first appearance of Rodlet cells in carp (Cyprinus carpio L.) ontogeny and their possible roles during stress and parasite infection. Fish and Shellfish Immunology. 2007, 22: 27-37. 10.1016/j.fsi.2006.03.012.

    Article  CAS  Google Scholar 

  56. Li Y, Cao H, He S, Yang X: Isolation and identification of Aeromonas hydrophila strain X1 from Acipenser baerii and its antibiotic sensitivity. 2008, 38: 1186-1191. Institute of Microbiology, CAS,

    Google Scholar 

Download references

Acknowledgements

We are grateful to professor Jun Zhu (Department of Microbiology, MOA Key Laboratory of Microbiological Engineering of Agricultural Environment, Nanjing Agricultural University, Nanjing, China) for providing the reporter stain A. tumefaciens KYC 55. The work was supported by State 863 High-Technology R&D Project of China (2007AA100605).

Author information

Authors and Affiliations

Authors

Corresponding authors

Correspondence to Zhigang Zhou or Bin Yao.

Additional information

Competing interests

The authors declare that they have no competing interests.

Authors' contributions

RD performed the experiment and participated in data analysis and writing of the manuscript. ZZ and YC participated in the design of the research and writing of the manuscript. YB performed fermentation of recombinant AiiAB546 in fermenter and participated in data analysis. BY participated in the design of the research and editorial supervision of the manuscript. All authors have read and approved the final version of the manuscript.

Authors’ original submitted files for images

Rights and permissions

Open Access This article is published under license to BioMed Central Ltd. This is an Open Access article is distributed under the terms of the Creative Commons Attribution License ( https://creativecommons.org/licenses/by/2.0 ), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Reprints and permissions

About this article

Cite this article

Chen, R., Zhou, Z., Cao, Y. et al. High yield expression of an AHL-lactonase from Bacillus sp. B546 in Pichia pastoris and its application to reduce Aeromonas hydrophila mortality in aquaculture. Microb Cell Fact 9, 39 (2010). https://doi.org/10.1186/1475-2859-9-39

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/1475-2859-9-39

Keywords